Mercury Mariner Recall Information
NEWS: Ford is recalling certain 2010-2012 Ford Escape and 2010-2011 Mercury Mariner vehicles; FUEL SYSTEM, GASOLINE
NOVEMBER 2016 -- Ford Motor Company (Ford) is recalling certain model year 2010-2012 Ford Escape vehicles manufactured February 26, 2009, to April 29, 2012, and 2010-2011 Mercury Mariner vehicles manufactured February 25, 2009, to December 12, 2010. On vehicles with a 3.0L engine, the Fuel Delivery Module (FDM) may crack, causing a fuel leak. A fuel leak in the presence of an ignition source increases the risk of a fire. Ford will notify owners, and dealers will replace the FDM flange with one that has a redesigned fuel supply port, free of charge. The recall is expected to begin December 12, 2016. Ford's number for this recall is 16S41. Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
MORE RECALL INFO
NEWS: Ford is recalling certain 2008-2011 Ford Escape and Mercury Mariner vehicles; POWER STEERING
JUNE 2014 -- Ford Motor Company (Ford) is recalling certain model year 2008-2011 Ford Escape and Mercury Mariner vehicles manufactured August 18, 2006, through September 11, 2010. The affected vehicles have a steering torque sensor that may not be able to properly detect driver steering input. As a result, the system could remove the Electric Power Steering (EPS) assist. If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash. Ford will notify owners, and dealers will update the software for the power steering control module (PSCM) and the instrument cluster module, free of charge. If a vehicle shows a history of a loss of the torque sensor signal or fault codes relating to the PSCM when the vehicle is brought in for the recall remedy, the affected components will be replaced, free of charge. The recall is expected to begin by July 25, 2014. Ford's number for this recall is 14S05. Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
MORE RECALL INFO:
NEWS: Feds probe 724K Ford models over power loss
FEBRUARY 2013 -- Federal safety regulators have opened a new safety investigation into 724,000 Ford Escape, Fusion and Mercury models over hundreds of reports of sudden loss of engine power.
The National Highway Traffic Safety Administration said Monday it has opened a preliminary investigation into the 2009-11 Ford Escape and Fusion, and Mercury Mariner and Milan. NHTSA said it has 123 reports indicating allegations of reduced power or vehicle stall in Escape vehicles under investigation.
Ford made a design change in 2009 to address complaints but did not recall the vehicles. NHTSA said there have been 27,500 warranty claims for the issue, along with reports of three crashes and one injury. Ford has received more than 1,400 complaints about the issue.
"We are cooperating fully with NHTSA on this investigation, as we do on all investigations," said Ford spokeswomanr.
Vehicles manufactured between June 2009 and October 2009 may contain contaminated circuit boards with plating variations, NHTSA said. Plating variations could lead to a failure. Ford and its supplier, Delphi Corp., modified the manufacturing process and issued a technical service bulletin in October 2010, NHTSA said.
Vehicles produced after Oct. 15, 2009 have electronic throttle bodies manufactured with a new process that resolved this condition, the government said. The bulletin instructed dealers to replace the throttle body on a number of Ford and Lincoln vehicles. Depending on the condition of throttle control system malfunction, a driver may experience varying levels of reduced engine performance.
Vehicles are not likely to unexpectedly stall as a result, but drivers may describe it as a stall even though the engine is still running, NHTSA said. Separately, NHTSA said it received 59 complaints alleging incidents of engine stalling while driving in model year 2010-11 Ford Fusions.
About 60 percent of the incidents occurred at speeds of 40 miles per hour or more.
MORE RECALL INFO:
WASHINGTON (AP) - November 17, 2005. Ford Motor Co. is recalling about 235,000 pickups, vans and sport utility vehicles from the 2006 model year because of potential problems with the windshield wiper motor.
The models include the E-150, E-250, E-350 and E-450 vans, the Escape, Expedition and Explorer SUVs, F-150 and Ranger pickups and Taurus sedan. It also includes the Lincoln Navigator SUV and Lincoln Mark LT pickup and Mercury Mountaineer and Mariner SUV.
It is Ford’s second large recall in two days. On Wednesday, the automaker said it was recalling 220,000 vehicles from the 2005 model year amid concerns a battery cable rubbing against the frame could cause fires and worry that a fuel tank strap could separate after tens of thousands of miles. MORE...