Search Recalls by Model or NHTSA Recall ID
Kia Recalls
| Vehicle Recalls |
|---|
| Report Receipt Date: March 31, 2023 NHTSA CAMPAIGN NUMBER: 23V236000 Power Sliding Door May Close on Occupant A power sliding door that does not auto-reverse can close on an occupant, increasing the risk of injury. NHTSA Campaign Number: 23V236000 Manufacturer: Kia America, Inc. Component(s): STRUCTURE Potential Number of Units Affected: 51,568 MARCH 2023 -- Kia America, Inc. (Kia) is recalling all 2022 and certain 2023 Carnival vehicles. The auto-reverse feature for the power sliding doors (PSD) may not activate in all situations. Dealers will update the power sliding door control module software, free of charge. Owner notification letters are expected to be mailed April 28, 2023. Kia's number for this recall is SC266. |
| Report Receipt Date: March 29, 2023 NHTSA CAMPAIGN NUMBER: 23V218000 High-Voltage Battery Pack May Short-Circuit A battery electrical short-circuit increases the risk of a fire. NHTSA Campaign Number: 23V218000 Manufacturer: Kia America, Inc. Component(s): ELECTRICAL SYSTEM Potential Number of Units Affected: 2,689 MARCH 2023 -- Kia America, Inc. (Kia) is recalling certain 2015-2019 Soul EV vehicles equipped with an E400 battery. The high-voltage battery pack may experience an electrical short-circuit while driving. Dealers will update the battery management system software, free of charge. The new software will illuminate the EV warning light, limit charging capacity, and reduce vehicle power if abnormal voltage is detected. If this occurs, the battery will be replaced, free of charge. Owner notification letters are expected to be mailed May 26, 2023. Kia's number for this recall is SC267. |
| Report Receipt Date: March 17, 2023 NHTSA CAMPAIGN NUMBER: 23V179000 Tow Hitch Harness Fire While Parked or Driving A fire while parked or driving can increase the risk of injury. NHTSA Campaign Number: 23V179000 Manufacturer: Kia America, Inc. Component(s): TRAILER HITCHES Potential Number of Units Affected: 3,555 MARCH 2023 -- Kia America, Inc. (Kia) is recalling certain 2022-2023 Carnival vehicles equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Kia dealership. Water accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire. Owners are advised to park their vehicles outside and away from structures until the remedy is completed. Dealers will inspect and verify whether the vehicle is equipped with a Genuine Kia accessory trailer tow hitch assembly. If equipped, dealers will install a new fuse and wire extension kit. Repairs will be performed free of charge. Owner notification letters are expected to be mailed May 16, 2023. Kia's number for this recall is SC265. |
| Report Receipt Date: March 7, 2023 NHTSA CAMPAIGN NUMBER: 23V149000 Side Curtain Air Bags May Not Deploy Properly Air bags that do not deploy as intended can increase the risk of injury in a crash. NHTSA Campaign Number: 23V149000 Manufacturer: Kia America, Inc. Component(s): AIR BAGS Potential Number of Units Affected: 188,912 MARCH 2023 -- Kia America, Inc. (Kia) is recalling certain 2021-2023 K5 vehicles. The side curtain air bags may have been installed incorrectly, causing them not to deploy properly in the event of a crash. Dealers will inspect and reinstall the side curtain air bags, as necessary, free of charge. Owner notification letters are expected to be mailed April 7, 2023. Kia's number for this recall is SC263. |
| Report Receipt Date: January 29, 2023 NHTSA CAMPAIGN NUMBER: 23V035000 Second Row Side Air Bags May Not Deploy Air bags that do not deploy as intended can increase the risk of injury in a crash. Report Receipt Date: 23V035000 Manufacturer: Kia America, Inc. Component(s): AIR BAGS Potential Number of Units Affected: 31,943 JANUARY 2023 -- Kia America, Inc. (Kia) is recalling certain 2023 Telluride vehicles. Due to a manufacturing error, the wire harness for the second row seat side air bags may become damaged, causing them not to deploy in the event of a crash. Dealers will inspect and replace, or secure the air bag wire harnesses, as necessary, free of charge. Owner notification letters are expected to be mailed February 28, 2023. Kia's number for this recall is SC262. |
| Report Receipt Date: January 25, 2023 NHTSA CAMPAIGN NUMBER: 23V027000 Improperly Molded Fuel Tank May Leak A fuel leak in the presence of an ignition source can increase the risk of a fire. Report Receipt Date: 23V027000 Manufacturer: Kia America, Inc. Component(s): FUEL SYSTEM, GASOLINE Potential Number of Units Affected: 34 JANUARY 2023 -- Kia America, Inc. (Kia) is recalling certain 2022 Sorento Plug-In Hybrid (PHEV) vehicles. The fuel tank may have been improperly molded, which can result in a fuel leak. Deales will inspect and replace the fuel tank, as necessary, free of charge. Owner notification letters are expected to be mailed March 22, 2023. Kia's number for this recall is SC261. |
| Report Receipt Date: December 8, 2022 NHTSA CAMPAIGN NUMBER: 22V906000 Loss of Steering Control from Cracked Knuckle A loss of steering control increases the risk of a crash. NHTSA Campaign Number: 22V906000 Manufacturer: Kia America, Inc. Component(s): STEERING Potential Number of Units Affected: 939 DECEMBER 2022 -- Kia America, Inc. (Kia) is recalling certain 2023 Forte vehicles. Due to a manufacturing error, the front left steering knuckle may crack, which can result in a loss of steering control.Dealers will inspect and replace the front left steering knuckle, as necessary, free of charge. Owner notification letters are expected to be mailed January 12, 2023. Kia's number for this recall is SC259. |
| Report Receipt Date: December 6, 2022 NHTSA CAMPAIGN NUMBER: 22V899000 Coolant Leak in EPCU may Cause Loss of Drive Power Coolant contacting the EPCU circuit board may cause a loss of drive power, increasing the risk of a crash. NHTSA Campaign Number: 22V899000 Manufacturer: Kia America, Inc. Component(s): ELECTRICAL SYSTEM Potential Number of Units Affected: 872 DECEMBER 2022 -- Kia America, Inc. (Kia) is recalling certain 2020 Niro EV vehicles. The Electric Power Control Unit (EPCU) may have been improperly sealed and may leak coolant internally. Dealers will inspect and replace the EPCU as necessary, free of charge. Owner notification letters are expected to be mailed January 31, 2023. Kia's number for this recall is SC258. |
| Report Receipt Date: November 28, 2022 NHTSA CAMPAIGN NUMBER: 22V878000 Side Curtain Air Bags Can Deploy Improperly A twisted air bag can deploy improperly, increasing the risk of injury. NHTSA Campaign Number: 22V878000 Manufacturer: Kia America, Inc. Component(s): AIR BAGS Potential Number of Units Affected: 76,918 NOVEMBER 2022 -- Kia America, Inc. (Kia) is recalling certain 2023 Sportage vehicles. The side curtain air bags may have been twisted during installation. Dealers will inspect and reinstall the side curtain air bags as necessary, free of charge. Owner notification letters are expected to be mailed December 28, 2022. Kia's number for this recall is SC257. |
| Report Receipt Date: November 11, 2022 NHTSA CAMPAIGN NUMBER: 22V836000 Electrical Resistance at Main Relay May Cause Fire Overheated rear seats increase the risk of a fire. NHTSA Campaign Number: 22V836000 Manufacturer: Kia America, Inc. Component(s): HYBRID PROPULSION SYSTEM Potential Number of Units Affected: 27,030 NOVEMBER 2022 -- Kia Motors America (Kia) is recalling certain 2017-2018 Kia Niro hybrid electric vehicles previously recalled under recall 18V-666. The Main Relay within the Power Relay Assembly (PRA) may have inadequate connections between its contacts, causing increased electrical resistance, which can overheat the rear seats. Dealers will inspect the PRA and replace either the PRA or the Main Relay, as necessary, free of charge. Owner notification letters are expected to be mailed January 9, 2023. Kia's number for this recall is SC256. This recall supersedes NHTSA recall number 18V-666. Vehicles already repaired under the previous recall will need to have the new remedy completed. |
| Report Receipt Date: October 24, 2022 NHTSA CAMPAIGN NUMBER: 22V800000 Engine Compartment Fire A fire increases the risk of injury. NHTSA Campaign Number: 22V800000 Manufacturer: Kia America, Inc. Component(s): SERVICE BRAKES, HYDRAULIC Potential Number of Units Affected: 71,704 OCTOBER 2022 -- Kia America, Inc. (Kia) is recalling certain 2008-2009 Sportage vehicles previously recalled under recall 16V-815. An engine compartment fire originating from around the Hydraulic Electronic Control Unit (HECU) may occur while parked or driving. Owners are advised to park outside and away from structures and other vehicles until the recall repair has been performed. The remedy is currently under development. Owner notification letters are expected to be mailed December 22, 2022. Kia's number for this recall is SC253. |
| Report Receipt Date: October 11, 2022 NHTSA CAMPAIGN NUMBER: 22V760000 Loss of Drive Power Loss of drive power increases the risk of a crash. NHTSA Campaign Number: 22V760000 Manufacturer: Kia America, Inc. Component(s): POWER TRAIN Potential Number of Units Affected: 69,038 OCTOBER 2022 -- Kia Motors, Inc. (Kia) is recalling certain 2021-2022 Sorento and 2021-2023 K5 vehicles. The vehicle's "fail-safe" limited-mobility drive mode may be impaired, when prompted by a transmission oil pump malfunction, which can result in a complete loss of drive power. Dealers will inspect and replace the transmission, as necessary. Dealers will also update the transmission control unit software. All repairs will be performed free of charge. Owner notification letters are expected to be mailed December 9, 2022. Kia's number for this recall is SC250. |
| Report Receipt Date: September 19, 2022 NHTSA CAMPAIGN NUMBER: 22V703000 Tow Hitch Harness Fire While Parked or Driving A fire while parked or driving can increase the risk of injury. NHTSA Campaign Number: 22V703000 Manufacturer: Kia America, Inc. Component(s): TRAILER HITCHES Potential Number of Units Affected: 70,887 SEPTEMBER 2022 -- Kia America, Inc. (Kia) is recalling certain 2016-2022 Sorento, 2021-2022 Sorento Hybrid (HEV), 2022-2023 Sorento Plug-In Hybrid (PHEV), and 2017-2022 Sportage vehicles equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Kia dealership. Debris and moisture accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire. Owners are advised to park outside and away from structures until the recall repair is complete. The remedy is currently under development. Owner notification letters are expected to be mailed November 14, 2022. Kia's number for this recall is SC249. |
| Report Receipt Date: August 29, 2022 NHTSA CAMPAIGN NUMBER: 22V651000 Loose Alternator Battery Nut An engine stall increases the risk of a crash, and an electrical surge increases the risk of a fire. NHTSA Campaign Number: 22V651000 Manufacturer: Kia America, Inc. Component(s): ELECTRICAL SYSTEM Potential Number of Units Affected: 19,701 AUGUST 2022 -- Kia America, Inc. (Kia) is recalling certain 2023 Sportage vehicles. The alternator battery positive terminal nut may loosen, which can result in an engine stall or an electrical surge. Dealers will inspect and tighten the alternator battery positive terminal nut, as necessary, free of charge. Owner notification letters were mailed September 23, 2022. Kia's number for this recall is SC248. |
| Report Receipt Date: August 15, 2022 NHTSA CAMPAIGN NUMBER: 22V626000 Tow Hitch Harness Fire While Parked or Driving A fire while parked or driving can increase the risk of injury. NHTSA Campaign Number: 22V626000 Manufacturer: Kia America, Inc. Component(s): TRAILER HITCHES Potential Number of Units Affected: 36,417 AUGUST 2022 -- Kia America, Inc. (Kia) is recalling certain 2020-2022 Telluride vehicles potentially equipped with a Genuine Kia 4-pin tow hitch harness installed as original equipment, or purchased as an accessory through a Kia dealership. Debris and moisture accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire. Owners are advised to park outside and away from structures until the recall repair is complete. The remedy is currently under development. Owner notification letters are expected to be mailed October 14, 2022. Kia's number for this recall is SC247. |
| Report Receipt Date: August 10, 2022 NHTSA CAMPAIGN NUMBER: 22V612000 Vehicle Rollaway from Faulty Shift Lever Assembly A vehicle rollaway increases the risk of a crash and injury. NHTSA Campaign Number: 22V612000 Manufacturer: Kia America, Inc. Component(s): POWER TRAIN Potential Number of Units Affected: 28,065 AUGUST 2022 -- Kia America, Inc. (Kia) is recalling certain 2016 Sedona and Sorento vehicles. The vehicles may have been manufactured with faulty automatic transmission shift lever assembly components, preventing the shift lever from locking, which can allow the vehicle to rollaway. Dealers will inspect and replace the automatic transmission shift lever assembly components, as necessary, free of charge. Owner notification letters are expected to be mailed October 7, 2022. Kia's number for this recall is SC246. |
| Report Receipt Date: August 1, 2022 NHTSA CAMPAIGN NUMBER: 22V560000 Headliner Plate Detachment A plate that detaches during a crash may strike an occupant, increasing their risk of injury. NHTSA Campaign Number: 22V560000 Manufacturer: Kia Motors America Component(s): STRUCTURE Potential Number of Units Affected: 257,998 AUGUST 2022 -- Kia America, Inc. (Kia) is recalling certain 2012-2013 Optima vehicles. The right and left headliner plates may not be secured properly, which can result in the plates detaching in the event of a side curtain air bag deployment. Dealers will secure the headliner plates, free of charge. Owner notification letters are expected to be mailed September 26, 2022. Kia's number for this recall is SC245. |
| Report Receipt Date: June 23, 2022 NHTSA CAMPAIGN NUMBER: 22V447000 Seat Belt Pretensioners May Explode An exploding seat belt pretensioner can project metal fragments into the vehicle, striking vehicle occupants and resulting in injury. NHTSA Campaign Number: 22V447000 Manufacturer: Kia Motors America Component(s): SEAT BELTS Potential Number of Units Affected: 17,199 JUNE 2022 -- Kia Motors America (Kia) is recalling certain 2021-2022 Sorento Hybrid and 2022 Sorento Plug-in Hybrid vehicles. In the event of a crash, the front driver-side and/or passenger-side seat belt pretensioner(s) may explode upon deployment. Dealers will secure the seat belt pretensioners with a cap, free of charge. Owner notification letters are expected to be mailed August 19, 2022. Kia's number for this recall is SC241. This recall expands and replaces NHTSA recall number 22V-127. Vehicles already repaired under the previous recall will need to have the new remedy completed. |
| Report Receipt Date: May 17, 2022 NHTSA CAMPAIGN NUMBER: 22V344000 Blank Instrument Cluster Display Screen/FMVSS 101 A blank instrument cluster display screen will not show critical information, such as the odometer, which can increase the risk of a crash. NHTSA Campaign Number: 22V344000 Manufacturer: Kia Motors America Component(s): ELECTRICAL SYSTEM Potential Number of Units Affected: 2,761 MAY 2022 -- Kia Motors America (Kia) is recalling certain 2022 Telluride vehicles. Excess adhesive in a circuit board within the instrument cluster may cause the instrument cluster display screen to be blank. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 101, "Control and Displays." Dealers will replace the instrument cluster assembly, free of charge. Owner notification letters are expected to be mailed July 15, 2022. Kia's number for this recall is SC237. |
| Report Receipt Date: May 5, 2022 NHTSA CAMPAIGN NUMBER: 22V304000 Unsecured Steering Column Loss of steering control can increase the risk of a crash. NHTSA Campaign Number: 22V304000 Manufacturer: Kia Motors America Component(s): STEERING Potential Number of Units Affected: 30 MAY 2022 -- Kia Motors America (Kia) is recalling certain 2021-2022 Rio and Forte vehicles. A bolt in the steering column may not be secured properly, which can cause the steering column to detach from the steering rack and result in a loss of steering control. Dealers will tighten the lower steering column u-joint retention bolt, free of charge. Owner notification letters are expected to be mailed May 27, 2022. Kia's number for this recall SC235. |
| Report Receipt Date: May 11, 2022 NHTSA CAMPAIGN NUMBER: 22V322000 Vehicle Rollaway from Software Error Vehicle rollaway can increase the risk of a crash or injury. NHTSA Campaign Number: 22V322000 Manufacturer: Kia Motors America Component(s): PARKING BRAKE Potential Number of Units Affected: 9,014 MAY 2022 -- Kia Motor America (Kia) is recalling certain 2022 EV6 vehicles. A software error in the Shifter Control Unit (SCU) may disengage the parking mechanism, which can allow the vehicle to rollaway. Drivers are recommended to park their vehicles on level ground and avoid parking on a slope/inclined surface whenever possible until the remedy has been performed. Dealers will update the Shifter Control Unit software, free of charge. Owner notification letters are expected to be mailed May 25, 2022. Kia's number for this recall is SC236. |
| Report Receipt Date: March 29, 2022 NHTSA CAMPAIGN NUMBER: 22V202000 Turbocharger Oil Supply Pipe May Leak An oil leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire. NHTSA Campaign Number: 22V202000 Manufacturer: Kia Motors America Component(s): ENGINE AND ENGINE COOLING Potential Number of Units Affected: 26 MARCH 2022 -- Kia Motor America (Kia) is recalling certain 2022 Sorento vehicles. The oil supply pipe to the turbocharger may crack, which could result in an oil leak in the engine compartment. Dealers will replace the turbocharger oil supply pipe, free of charge. Owner notification letters are expected to be mailed April 22, 2022. Kia's number for this recall is SC233. |
| Report Receipt Date: March 15, 2022 NHTSA CAMPAIGN NUMBER: 22V158000 Inadequate Windshield Bonding A front windshield that detaches from a vehicle can increase the risk of a crash or injury. NHTSA Campaign Number: 22V158000 Manufacturer: Kia Motors America Component(s): VISIBILITY Potential Number of Units Affected: 30,362 MARCH 2022 -- Kia Motors America (Kia) is recalling all 2014-2016 Cadenza vehicles. During manufacturing, the front windshield may not have been properly bonded to the vehicle, allowing it to detach. Dealers will inspect the front windshield glass. If necessary, the windshield will be removed and reinstalled. Repairs will be performed free of charge. Owner notification letters are expected to be mailed May 13, 2022. Kia's number for this recall is SC232. |
| Report Receipt Date: March 4, 2022 NHTSA CAMPAIGN NUMBER: 22V127000 Seat Belt Pretensioners May Explode An exploding seat belt pretensioner can project metal fragments into the vehicle, striking vehicle occupants and resulting in injury. NHTSA Campaign Number: 22V127000 Manufacturer: Kia Motors America Component(s): SEAT BELTS Potential Number of Units Affected: 213 MARCH 2022 -- Kia Motors America (Kia) is recalling certain 2022 Sorento Hybrid and Sorento Plug-in Hybrid vehicles. In the event of a crash, the front driver-side and/or passenger-side seat belt pretensioner(s) may explode upon deployment. Dealers will replace the seatbelt pretensioner(s), free of charge. Owner notification letters are expected to be mailed May 3, 2022. Kia's number for this recall is SC231. |
| Report Receipt Date: February 18, 2022 NHTSA CAMPAIGN NUMBER: 22V096000 Front Air Bags May Not Deploy Front air bags that do not deploy as intended can increase the risk of injury in a crash. NHTSA Campaign Number: 22V096000 Manufacturer: Kia Motors America Component(s): AIR BAGS Potential Number of Units Affected: 128,280 FEBRUARY 2022 -- Kia Motors America (Kia) is recalling certain 2014 Soul vehicles. The front air bags may not deploy during a crash if the Air Bag Control Unit (ACU) loses communication with the front impact sensors. Dealers will update the ACU software, free of charge. Owner notification letters are expected to be mailed April 15, 2022. Kia's number for this recall is SC229. |
| Report Receipt Date: February 17, 2022 NHTSA CAMPAIGN NUMBER: 22V093000 Low Pressure Fuel Hose May Leak A fuel leak can increase the risk of a fire. NHTSA Campaign Number: 22V093000 Manufacturer: Kia Motors America Component(s): FUEL SYSTEM, GASOLINE Potential Number of Units Affected: 72,848 FEBRUARY 2022 -- Kia Motors America (Kia) is recalling certain 2013-2014 Optima vehicles that were previously repaired under NHTSA recall number 20V-100. The low pressure fuel hose may be damaged, or missing heat-protective tape, which can result in a fuel leak. Dealers will replace the low pressure fuel hose, free of charge. Owner notification letters are expected to be mailed April 15, 2022. Kia's number for this recall is SC228. |
| Report Receipt Date: February 2, 2022 NHTSA CAMPAIGN NUMBER: 22V051000 Engine Compartment Fire An engine compartment fire while parked or driving can increase the risk of injury. NHTSA Campaign Number: 22V051000 Manufacturer: Kia Motors America Component(s): SERVICE BRAKES, HYDRAULIC Potential Number of Units Affected: 126,747 FEBRUARY 2022 -- Kia Motors America (Kia) is recalling certain 2016-2018 K900 and 2014-2016 Sportage vehicles. The Hydraulic Electronic Control Unit (HECU) module could malfunction and cause an electrical short, which could result in an engine compartment fire. Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will install a new fuse for the HECU circuit board, free of charge. Owner notification letters are expected to be mailed March 31, 2022. Kia's number for this recall is SC227. |
| Report Receipt Date: January 25, 2022 NHTSA CAMPAIGN NUMBER: 22V031000 Air Bags May Not Deploy Air bags that do not deploy as intended can increase the risk of injury in a crash. NHTSA Campaign Number: 22V031000 Manufacturer: Kia Motors America Component(s): AIR BAGS Potential Number of Units Affected: 410,619 JANUARY 2022 -- Kia Motors America (Kia) is recalling certain 2017-2019 Sedona, Soul, Soul EV, 2017-2018 Forte, and 2017 Forte Koup vehicles. The Air Bag Control Unit (ACU) cover may contact a memory chip on the printed circuit board and damage the electrical circuit. Circuit damage may result in deactivated air bags that will not deploy in a crash. Dealers will inspect the ACU, and either update the software or replace the unit, as necessary. Repairs will be performed free of charge. Owner notification letters are expected to be mailed March 21, 2022. Kia's number for this recall is SC226. |
| Report Receipt Date: January 21, 2022 NHTSA CAMPAIGN NUMBER: 22V022000 Rear Windows May Operate Unexpectedly/FMVSS 118 Rear power windows that operate unexpectedly can increase the risk of injury. NHTSA Campaign Number: 22V022000 Manufacturer: Kia Motors America Component(s): VISIBILITY, ELECTRICAL SYSTEM Potential Number of Units Affected: 451 JANUARY 2022 -- Kia Motors America (Kia) is recalling certain 2020 Cadenza vehicles. The rear power windows can be operated by the driver's power window main switch after the ignition has been turned off and a front door is opened. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 118, "Power-Operated Window Systems." Dealers will update the Driver Door Module software, free of charge. Owner notification letters are expected to be mailed March 8, 2022. Kia's number for this recall is SC225. |
| Report Receipt Date: December 1, 2021 NHTSA CAMPAIGN NUMBER: 21V936000 Reduced Braking Performance Reduced braking performance can cause longer brake pedal travel or extend the distance required to stop the vehicle, increasing the risk of a crash. NHTSA Campaign Number: 21V936000 Manufacturer: Kia Motors America Component(s): SERVICE BRAKES, HYDRAULIC Potential Number of Units Affected: 87 DECEMBER 2021 -- Kia Motors America (Kia) is recalling certain 2020-2021 Rio vehicles. The brake master cylinder may have been manufactured with sharp edges that can damage the inner oil seal, resulting in reduced braking performance. Dealers will replace the brake master cylinder, free of charge. Owner notification letters are expected to be mailed January 11, 2022. Kia's number for this recall SC223. |
| Report Receipt Date: November 19, 2021 NHTSA CAMPAIGN NUMBER: 21V908000 Passenger-Side Sliding Door May Not Latch A power sliding door that fails to latch may open while moving, increasing the risk of injury. NHTSA Campaign Number: 21V908000 Manufacturer: Kia Motors America Component(s): STRUCTURE, LATCHES/LOCKS/LINKAGES Potential Number of Units Affected: 2,956 NOVEMBER 2021 -- Kia Motors America (Kia) is recalling certain 2022 Carnival vehicles. The remote controller assembly for the passenger-side power sliding door may malfunction, preventing the passenger-side sliding door from securely latching. Dealers will replace the passenger-side power sliding door release actuator's drum and holder inside the remote controller assembly, free of charge. Owner notification letters are expected to be mailed December 16, 2021. Kia's number for this recall is SC221. |
| Report Receipt Date: November 5, 2021 NHTSA CAMPAIGN NUMBER: 21V862000 Inaccurate Fuel Gauge Reading An inaccurate fuel gauge may result in the vehicle unexpectedly running out of fuel and stalling, increasing the risk of a crash. NHTSA Campaign Number: 21V862000 Manufacturer: Kia Motors America Component(s): ELECTRICAL SYSTEM Potential Number of Units Affected: 53 NOVEMBER 2021 -- Kia Motors America (Kia) is recalling certain 2020-2021 Stinger vehicles. A software error in the instrument cluster may cause an inaccurate fuel gauge reading. Dealers will update the software, free of charge. Owner notification letters are expected to be mailed December 10, 2021. Kia's number for this recall is SC219. |
| Report Receipt Date: October 29, 2021 NHTSA CAMPAIGN NUMBER: 21V844000 Engine Damage May Cause Stall or Fire A damaged engine can increase the risk of a fire or it can cause an engine stall, increasing the risk of a crash. NHTSA Campaign Number: 21V844000 Manufacturer: Kia Motors America Component(s): ENGINE Potential Number of Units Affected: 10,731 OCTOBER 2021 -- Kia Motors America (Kia) is recalling certain 2017-2018 Optima Hybrid and Optima Plug-In Hybrid vehicles. The connecting rod bearings inside the engine may wear prematurely, which can result in engine damage. Dealers will inspect the engine. If bearing damage is found, the engine will be replaced. Dealers will also install a software update containing a Knock Sensor Detection System (KSDS). Repairs will be performed free of charge. Owner notification letters are expected to be mailed November 29, 2021. Kia's number for this recall is SC218. |
| Report Receipt Date: September 17, 2021 NHTSA CAMPAIGN NUMBER: 21V725000 Turn Signal May Activate in Wrong Direction A turn signal activating in the opposite direction of what was intended by the driver increases the risk of a crash. NHTSA Campaign Number: 21V725000 Manufacturer: Kia Motors America Component(s): EXTERIOR LIGHTING, ELECTRICAL SYSTEM Potential Number of Units Affected: 88,576 SEPTEMBER 2021 -- Kia Motors America (Kia) is recalling certain 2015-2017 Sedona vehicles. The Smart Junction Box (SJB) software logic may not properly interpret the signals received from the multifunction switch, which could cause the turn signal to activate in the opposite direction of what the driver intended. Dealers will update the SJB software, free of charge. Owner notification letters are expected to be mailed November 12, 2021. Kia's number for this recall is SC217. |
| Report Receipt Date: August 9, 2021 NHTSA CAMPAIGN NUMBER: 21V622000 Trunk Emergency Release May Fail/FMVSS 401 A person inside the trunk compartment may become trapped, increasing their risk of injury. NHTSA Campaign Number: 21V622000 Manufacturer: Kia Motors America Component(s): LATCHES/LOCKS/LINKAGES Potential Number of Units Affected: 253,074 AUGUST 2021 -- Kia Motors America (Kia) is recalling certain 2016-2018 Forte 4-door, Forte Koup 2-door, and 2018-2019 Rio 4-door vehicles. The trunk latch may become damaged, preventing the opening of the trunk from the inside. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 401, "Internal Trunk Release." Dealers will replace the trunk latch assembly, free of charge. Owner notification letters are expected to be mailed October 5, 2021. Kia's number for this recall is SC216. |
| Report Receipt Date: July 28, 2021 NHTSA CAMPAIGN NUMBER: 21V577000 Blank LCD Display/FMVSS 101 A blank LCD display may be missing information, such as the digital speedometer, gear selection indicator, and odometer, which may increase the risk of a crash. NHTSA Campaign Number: 21V577000 Manufacturer: Kia Motors America Component(s): ELECTRICAL SYSTEM Potential Number of Units Affected: 5,143 JULY 2021 -- Kia Motors America (Kia) is recalling certain 2022 Telluride vehicles. The LCD display screen may remain blank after startup. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 101, "Control and Displays." Dealers will update the instrument cluster's software, free of charge. Owner notification letters are expected to be mailed in August 2021. Kia's number for this recall is SC215. |
| Report Receipt Date: July 8, 2021 NHTSA CAMPAIGN NUMBER: 21V519000 Fuel Leak at Pipe Connection A fuel leak increases the risk of a fire. NHTSA Campaign Number:21V519000 Manufacturer: Kia Motors America Component(s): FUEL SYSTEM, GASOLINE Potential Number of Units Affected: 21,575 JULY 2021 -- Kia Motor America (Kia) is recalling certain 2021 Sorento and 2021-2022 K5 vehicles equipped with 2.5L turbocharged engines. Fuel may leak at the pipe connection between the high-pressure fuel pump and fuel rail. Dealers will inspect and tighten, or replace the fuel pipe as necessary, free of charge. Owner notification letters are expected to be mailed July 21, 2021. Kia's number for this recall is SC214. |
| Report Receipt Date: June 14, 2021 NHTSA CAMPAIGN NUMBER: 21V447000 Steering Assist Level May Not Adjust Properly A sudden increase in steering effort can increase the risk of a crash. NHTSA Campaign Number:21V447000 Manufacturer: Kia Motors America Component(s): STEERING, LANE DEPARTURE Potential Number of Units Affected: 846 JUNE 2021-- Kia Motors America (Kia) is recalling certain 2021-2022 K5 vehicles equipped with 2.5L T-GDI engines. The Rack-Mounted Motor Driven Power Steering (R-MDPS) system lacks the ability to diagnose communication faults. If a communication fault occurs while driving around a curve with Lane Following Assist (LFA) engaged, the steering assist level may not adjust properly, causing a sudden increase in the steering effort required. Dealers will update the R-MDPS software, free of charge. Owner notification letters are were mailed June 24, 2021. Kia's number for this recall is SC213. |
| Report Receipt Date: May 10, 2021 NHTSA CAMPAIGN NUMBER: 21V331000 Hydraulic Electronic Control Unit May Short An electrical short in the HECU increases the risk of a fire while parked or driving. NHTSA Campaign Number: 21V331000 Manufacturer: Kia Motors America Component(s): SERVICE BRAKES, HYDRAULIC Potential Number of Units Affected: 440,370 MAY 2021 -- Kia Motors America (Kia) is recalling certain 2013-2015 Optima and 2014-2015 Sorento vehicles previously recalled under recall 20V-519. Brake fluid may leak inside the Hydraulic Electronic Control Unit (HECU), possibly resulting in an electrical short. Owners are advised to park outside and away from other vehicles and structures until the recall repair is completed. Dealers will install a new multi-fuse, and inspect the HECU for leaks, replacing the HECU if necessary, free of charge. Owner notification letters are expected to be mailed July 2, 2021. This recall supersedes previous NHTSA recall number 20V-519. Kia's number for this recall is SC212. |
| Report Receipt Date: April 21, 2021 NHTSA CAMPAIGN NUMBER: 21V277000 Fuel Rail Tube May Leak A damaged fuel rail tube may leak fuel, increasing the risk of a fire. NHTSA Campaign Number: 21V277000 Manufacturer: Kia Motors America Component(s): FUEL SYSTEM, GASOLINE Potential Number of Units Affected: 2,744 APRIL 2021 -- Kia Motors America (Kia) is recalling certain 2022 Carnival vehicles. The plastic fuel rail tube may have been damaged. Kia will notify owners, and dealers will inspect, and if necessary, replace the multi-port injection fuel rail, free of charge. The recall is expected to begin April 30, 2021. Kia's number for this recall is SC211. |
| Report Receipt Date: April 13, 2021 NHTSA CAMPAIGN NUMBER: 21V260000 Foreign Particles May Cause Oil Pump to Fail A damaged engine may stall, increasing the risk of a crash. NHTSA Campaign Number: 21V260000 Manufacturer: Kia Motors America Component(s): ENGINE AND ENGINE COOLING Potential Number of Units Affected: 4,069 APRIL 2021 -- Kia Motors America (Kia) is recalling certain 2017-2018 Forte vehicles equipped with a 2.0L Nu MPI engine. Foreign particles may stick inside the oil pump, which may cause an oil pump failure and engine damage. Kia will notify owners, and dealers will replace the oil pan, free of charge. The recall is expected to begin June 11, 2021. Kia's number for this recall is SC210. |
| Report Receipt Date: April 13, 2021 NHTSA CAMPAIGN NUMBER: 21V259000 Improperly Heat-Treated Piston Oil Rings A damaged engine may stall, increasing the risk of a crash. In addition, oil may leak onto hot exhaust components, increasing the risk of a fire. NHTSA Campaign Number: 21V259000 Manufacturer: Kia Motors America Component(s): ENGINE Potential Number of Units Affected: 147,249 APRIL 2021 -- Kia Motors America (Kia) is recalling certain 2020-2021 Soul, and 2021 Seltos vehicles equipped with 2.0L Nu MPI engines. The piston oil rings may not have been properly heat-treated, which may result in engine damage. Kia will notify owners, and dealers will inspect and, if necessary, replace the engine, free of charge. In addition, Kia will deploy Piston Ring Noise Sensing System (PNSS) software. The recall is expected to begin June 11, 2021. Kia's number for this recall is SC209. |
| Report Receipt Date: March 11, 2021 NHTSA CAMPAIGN NUMBER: 21V164000 Occupant Detection System Malfunction/FMVSS 208 In the event of a crash, deployment of the front passenger air bag, with a child in that seat, can increase the risk of injury to the child. NHTSA Campaign Number: 21V164000 Manufacturer: Kia Motors America Component(s): AIR BAGS Potential Number of Units Affected: 142 MARCH 2021 -- Kia Motors America (Kia) is recalling certain 2021 Telluride, K5, and Forte vehicles. The Occupant Classification and Detection System (OCS/ODS) unit may not detect the presence of a child restraint system in the front passenger seat. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection." Kia will notify owners, and dealers will replace the OCS/ODS unit, free of charge. The recall began March 18, 2021. Kia's number for this recall is SC207. |
| Report Receipt Date: March 4, 2021 NHTSA CAMPAIGN NUMBER: 21V137000 Engine Compartment Fire An engine compartment fire can increase the risk of injury. NHTSA Campaign Number: 21V137000 Manufacturer: Kia Motors America Component(s): SERVICE BRAKES, HYDRAULIC Potential Number of Units Affected: 379,931 MARCH 2021 -- Kia Motors America (Kia) is recalling certain 2017-2021 Sportage and Cadenza vehicles. The electrical circuit in the Hydraulic Electronic Control Unit (HECU) may short-circuit, which can cause a fire in the engine compartment. Kia will notify owners, and dealers will replace certain fuses in the electrical junction box. Vehicles equipped with an electronic parking brake (EPB) will also receive a HECU software update. Repairs will be performed free of charge. Owners are advised to park outside and away from structures as a precaution until the recall repair is complete. The recall is expected to begin April 30, 2021. Kia's number for this recall is SC206. |
| Report Receipt Date: December 2, 2020 NHTSA CAMPAIGN NUMBER: 20V750000 Engine Damage May Cause Fire An engine compartment fire increases the risk of injury. NHTSA Campaign Number: 20V750000 Manufacturer: Kia Motors America Component(s): ENGINE Potential Number of Units Affected: 294,756 DECEMBER 2020 -- Kia Motors America (Kia) is recalling certain 2012-2013 Sorento, 2012-2015 Forte and Forte Koup, 2011-2013 Optima Hybrid, 2014-2015 Soul, and 2012 Sportage vehicles. An engine compartment fire can occur while driving. Kia will notify owners, and dealers will inspect the engine compartment for fuel and/or engine oil leaks, perform an engine test and make any repairs, including engine replacement, as necessary, free of charge. In addition, Kia is currently developing a Knock Sensor Detection System (KSDS) software update, which when available, will be performed by dealers free of charge. The recall is expected to begin January 27, 2021. Kia's number for this recall is SC200. |
| Report Receipt Date: September 16, 2020 NHTSA CAMPAIGN NUMBER: 20V560000 Insufficient Fuel Supply Insufficient fuel supply to the engine can result in a loss of drive power, increasing the risk of a crash. NHTSA Campaign Number: 20V560000 Manufacturer: Kia Motors America Component(s): FUEL SYSTEM, GASOLINE Potential Number of Units Affected: 635 SEPTEMBER 2020 -- Kia Motors America (Kia) is recalling certain 2020-2021 Stinger vehicles. The fuel pump's jet nozzle may have a plastic burr remaining from the manufacturing process, possibly causing a blocked nozzle and an insufficient fuel supply to the engine. Kia will notify owners, and dealers will inspect the fuel pump and replace the jet nozzle housing assembly, if necessary, free of charge. The recall is expected to begin October 29, 2020. Kia's number for this recall is SC198. |
| Report Receipt Date: August 27, 2020 NHTSA CAMPAIGN NUMBER: 20V519000 Hydraulic Electronic Control Unit May Short If the HECU short circuits, there is an increased risk of an engine compartment fire. NHTSA Campaign Number: 20V519000 Manufacturer: Kia Motors America Component(s): SERVICE BRAKES, HYDRAULIC Potential Number of Units Affected: 440,370 AUGUST 2020 -- Kia Motors America (Kia) is recalling certain 2013-2015 Optima and 2014-2015 Sorento vehicles. Brake fluid may leak inside the Hydraulic Electronic Control Unit (HECU), possibly resulting in an electrical short. Kia will notify owners, and dealers will inspect the HECU for leaking brake fluid and replace the HECU if necessary, free of charge. The recall is expected to begin October 15, 2020. Kia's number for this recall is SC197. |
| Report Receipt Date: August 27, 2020 NHTSA CAMPAIGN NUMBER: 20V518000 ABS Unit may cause Fire An engine compartment fire can increase the risk of injury or crash. NHTSA Campaign Number: 20V518000 Manufacturer: Kia Motors America Component(s): SERVICE BRAKES, HYDRAULIC Potential Number of Units Affected: 9,443 AUGUST 2020 -- Kia Motors America (Kia) is recalling certain 2019 Stinger vehicles equipped with 3.3L T-GDI engines. While driving, an engine compartment fire may occur in the area where the Anti-lock Brake Hydraulic Electronic Control Unit (HECU) is located. The remedy for this recall is still under development. The recall is expected to begin October 26, 2020. Kia's number for this recall is SC196. |
| Report Receipt Date: August 5, 2020 NHTSA CAMPAIGN NUMBER: 20V459000 Left Front Axle Driveshaft May Break A broken driveshaft can result in a sudden loss of drive power, increasing the risk of a crash. NHTSA Campaign Number: 20V459000 Manufacturer: Kia Motors America Component(s): POWER TRAIN Potential Number of Units Affected: 834 AUGUST 2020 -- Kia Motors America (Kia) is recalling certain 2019 Forte vehicles. The left front axle driveshaft may not have been heat-treated, which can cause it to break. Kia will notify owners, and dealers will inspect the left front axle driveshaft for a heat treatment verification code, and replace it if the code is missing, free of charge. The recall is expected to begin September 2, 2020. Kia's number for this recall is SC195. |
| Report Receipt Date: July 28, 2020 NHTSA CAMPAIGN NUMBER: 20V436000 Inoperative Trailer Brake Lights/FMVSS 108 Inoperative trailer brake lights can fail to warn other drivers that the vehicle is slowing, increasing the risk of a crash. NHTSA Campaign Number: 20V436000 Manufacturer: Kia Motors America Component(s): ELECTRICAL SYSTEM, EXTERIOR LIGHTING, FORWARD COLLISION AVOIDANCE Potential Number of Units Affected: 86,921 JULY 2020 -- Kia Motors America (Kia) is recalling certain 2020 Telluride vehicles equipped with Smart Cruise Control (SCC). When a trailer is connected to the vehicle, the trailer brake lights will not illuminate when the SCC applies the brakes. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment." Kia will notify owners, and dealers will install an additional wire harness to the main fuse box to signal the trailer brake lights, free of charge. The recall is expected to begin September 10, 2020. Kia's number for this recall is SC194. |
| Report Receipt Date: July 22, 2020 NHTSA CAMPAIGN NUMBER: 20V422000 Potential Loss of Steering Control A loss of steering control can increase the risk of a crash. NHTSA Campaign Number: 20V422000 Manufacturer: Kia Motors America Component(s): STEERING Potential Number of Units Affected: 104 JULY 2020 -- Kia Motors America (Kia) is recalling certain 2020 Stinger vehicles equipped with a 2.0L Turbo-GDI engine. A component within the Rack Mounted Motor Driven Power Steering (MDPS) Assembly may have been manufactured incorrectly, possibly resulting in the steering locking or becoming difficult while driving. Kia will notify owners, and dealers will replace the MDPS Assembly, free of charge. The recall is expected to begin August 28, 2020. Kia's number for this recall is SC193. |
| Report Receipt Date: July 8, 2020 NHTSA CAMPAIGN NUMBER: 20V399000 Alternator Terminal Nut May Loosen If the alternator B+ terminal nut loosens, electrical arcing may result, increasing the risk of a fire. NHTSA Campaign Number: 20V399000 Manufacturer: Kia Motors America Component(s):ELECTRICAL SYSTEM Potential Number of Units Affected: 5,385 JULY 2020 -- Kia Motors America (KIA) is recalling certain 2020 Sedona vehicles. The battery positive (B+) terminal nut on the alternator may not have been tightened properly during assembly, possibly causing it to loosen over time. Kia will notify owners, and dealers will inspect the alternator B+ terminal nut, tightening it as necessary, free of charge. The recall is expected to begin August 14, 2020. Kia's number for this recall is SC192. |
| Report Receipt Date: July 2, 2020 NHTSA CAMPAIGN NUMBER: 20V389000 Unintended Movement Due to Damaged Park Mechanism Unintended vehicle movement can increase the risk of a crash. NHTSA Campaign Number: 20V389000 Manufacturer: Kia Motors America Component(s):POWER TRAIN, ELECTRICAL SYSTEM Potential Number of Units Affected: 3,714 JULY 2020 -- Kia Motors America (Kia) is recalling certain 2015-2016 Kia Soul Electric Vehicle (EV) vehicles. The parking mechanism may become damaged if the driver moves the gear shift lever into Park 'P' before the vehicle comes to a complete stop. If the parking mechanism is damaged, unintended vehicle movement may occur when the gear shift lever is in the Park 'P' position and the parking brake is not applied. Kia will notify owners, and dealers will update the electronic control unit software, free of charge. The recall is expected to begin August 7, 2020. Kia's number for this recall is SC191. |
| Report Receipt Date: February 21, 2020 NHTSA CAMPAIGN NUMBER: 20V101000 Fuel Rail May Crack and Cause Fire A fuel leak increases the risk of fire. NHTSA Campaign Number: 20V101000 Manufacturer: Kia Motors America Component(s): FUEL SYSTEM, GASOLINE Potential Number of Units Affected: 51,465 FEBRUARY 2020 -- Kia Motors America (Kia) is recalling certain 2011-2012 Sedona vehicles. The fuel rail may crack from exposure to heat generated within the engine compartment, resulting in a fuel leak. Kia will notify owners, and dealers will replace the fuel rail, free of charge. The recall is expected to begin April 16, 2020. Kia's number for this recall is SC188. |
| Report Receipt Date: February 21, 2020 NHTSA CAMPAIGN NUMBER: 20V100000 Low Pressure Fuel Hose May Crack and Leak If the fuel hose cracks, a fuel leak can occur, increasing the risk of a fire. NHTSA Campaign Number: 20V100000 Manufacturer: Kia Motors America Component(s): FUEL SYSTEM, GASOLINE Potential Number of Units Affected: 141,774 FEBRUARY 2020 -- Kia Motors America (Kia) is recalling certain 2013-2014 Optima vehicles equipped with 2.4L Gasoline Direct Injection (GDI) or 2.0L GDI Turbo engines. The low pressure fuel hose may deteriorate and crack over time due to heat generated within the engine compartment. The remedy for this recall is still under development. The recall is expected to begin April 16, 2020. Kia's number for this recall is SC187. |
| Report Receipt Date: February 14, 2020 NHTSA CAMPAIGN NUMBER: 20V088000 ABS Module May Short Circuit An electrical short within the ABS Module may cause an engine compartment fire, even when the vehicle is turned off, increasing the risk of an injury. NHTSA Campaign Number: 20V088000 Manufacturer: Kia Motors America Component(s): ELECTRICAL SYSTEM, SERVICE BRAKES, HYDRAULIC Potential Number of Units Affected: 228,829 FEBRUARY 2020 -- Kia Motors America (Kia) is recalling certain 2006-2010 Sedona and 2007-2009 Sorento vehicles. Moisture may enter the Anti-lock Brake (ABS) Module and result in an electrical short. Kia will notify owners, and dealers will install a relay in the main junction box to prevent power from being directed to the HECU when the vehicle's ignition switch is turned off, free of charge. The recall is expected to begin April 10, 2020. Kia's number for this recall is SC186. |
| RECALL SUBJECT: Incorrect Seat Belt Assemblies Installed/FMVSS 208 Report Receipt Date: AUG 13, 2019 NHTSA Campaign Number: 19V594000 Component(s): SEAT BELTS Potential Number of Units Affected: 30,168 Manufacturer: Kia Motors America AUGUST 2019 -- Kia Motors America (Kia) is recalling certain 2020 Telluride vehicles. The seat belt assemblies in the front passenger, second, and/or third row seats may not tightly secure a child restraint system in the event of a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection." If a child seat is not properly secured, there is an increased risk of injury to the occupant in a crash. Kia will notify owners, and dealers will inspect the vehicles and replace any incorrect seat belt assemblies, free of charge. The recall began August 30, 2019. Kia's number for this recall is SC181. Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov. |
| RECALL SUBJECT:: Collision-Avoidance Assist may not Engage Report Receipt Date: JUL 19, 2019 NHTSA Campaign Number: 19V539000 Component(s):: FORWARD COLLISION AVOIDANCE Potential Number of Units Affected: 11,423 Manufacturer: Kia Motors America JULY 2019 -- Kia Motors America (Kia) is recalling certain 2019 Optima vehicles equipped with Gamma 1.6L Turbo-GDI or Theta II 2.0L Turbo-GDI engines. A software error in the Forward Collision-Avoidance Assist (FCA) system may cause the braking assist function to not engage when a stationary vehicle is detected. Improper intervention of the Forward Collision-Avoidance Assist can increase the risk of a crash. Kia will notify owners, and dealers will update the FCA software, free of charge. The recall is expected to begin August 27, 2019. Kia's number for this recall is SC179. Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov. |
| RECALL SUBJECT:: Seatbelt Buckle may be Improperly Installed Report Receipt Date: MAR 18, 2019 NHTSA Campaign Number: 19V207000 Component(s):: SEAT BELTS Potential Number of Units Affected: 197 Manufacturer: Kia Motors America APRIL 2019 -- Kia Motors America (Kia) is recalling certain 2019 Sedona vehicles equipped with an 8-passenger seat arrangement. The seat belt buckle for the second-row middle seat may have been improperly installed on the wrong side of the seat, preventing the proper use of the 3-point seat belt. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection." A seat belt that cannot be properly used increases the risk of injury in the event of a crash. Kia has notified owners, and dealers will inspect the seat belt installation, and reinstall the seat belt buckle to the correct side if necessary, free of charge. The recall began April 8, 2019. Kia 's number for this recall is SC177. Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov. |
| RECALL SUBJECT:: Overheated Catalytic Converter May Damage Engine , 1 INVESTIGATION(S) Report Receipt Date: FEB 22, 2019 NHTSA Campaign Number: 19V120000 Component(s):: ENGINE , ENGINE AND ENGINE COOLING Potential Number of Units Affected: 378,967 Manufacturer: Kia Motors America FEBRUARY 2019 -- Kia Motors America (Kia) is recalling certain 2012-2016 Kia Soul vehicles equipped with 1.6L Gasoline Direct Injection (GDI) engines. High exhaust gas temperatures may damage the catalytic converter, possibly resulting in abnormal engine combustion and damage to one or more of the engine's pistons and possible piston connecting rod failure. Piston damage may result in an engine stall, increasing the risk of crash. A broken connecting rod may puncture the engine block allowing engine oil to escape. The leaking oil may contact the exhaust, increasing the risk of a fire. Kia will notify owners, and dealers will upgrade the Catalytic Overheating Protection Engine Control Unit logic to prevent overheating of the catalytic converter. In addition, the catalytic converter will also be replaced if it has been damaged. Depending on the extent of any damage, the engine may also be replaced, free of charge. Kia's number for this recall is SC176. Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov. |
| RECALL SUBJECT:: Occupant Detection System Wire Harness May Break Report Receipt Date: FEB 19, 2019 NHTSA Campaign Number: 19V109000 Component(s):: ELECTRICAL SYSTEM Potential Number of Units Affected: 94,389 Manufacturer: Kia Motors America FEBRUARY 2019 -- Kia Motors America (Kia) is recalling certain 2015-2018 Sedona vehicles equipped with manually-adjusted front passenger seats. Over time, the Occupant Detection System (ODS) wiring harness located underneath the front passenger seat may break from the seat being occupied. If a child is in a child seat in the front seat, a broken ODS wiring harness will not prevent the front passenger air bag from deploying in the event of a crash, increasing the risk of injury to the child. Kia will notify owners, and dealers will remove the wire harness clip to prevent the wiring harness from breaking. If the harness is found damaged, the front passenger seat cushion will be replaced. These repairs will be performed free of charge. The recall is expected to begin March 19, 2019. Kia's number for this recall is SC175. Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov. |
| RECALL SUBJECT:: Engine Oil Leak May Cause Stall or Fire Report Receipt Date: FEB 15, 2019 NHTSA Campaign Number: 19V101000 Component(s):: ENGINE Potential Number of Units Affected: 32,296 Manufacturer: Kia Motors America FEBRUARY 2019 -- Kia Motors America (Kia) is recalling certain 2011-2012 Kia Sportage vehicles. The engine oil pan may leak and, if not addressed, the loss of oil may result in engine damage. A damaged engine can increase the risk of a fire or it can cause an engine stall, increasing the risk of a crash. The remedy for this recall is still under development. Kia will notify owners beginning April 10,2019. Kia's number for this recall is SC174. Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov |
| RECALL SUBJECT:: High Pressure Fuel Pipe May Leak , 1 INVESTIGATION(S) Report Receipt Date: DEC 19, 2018 NHTSA Campaign Number: 18V907000 Component(s):: ENGINE , FUEL SYSTEM, GASOLINE Potential Number of Units Affected: 71,653 Manufacturer: Kia Motors America DECEMBER 2018 -- Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V-224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned or improperly torqued during the engine replacement procedure, possibly causing a fuel leak. A fuel leak in the presence of an ignition source can increase the risk of a fire. Kia has notified owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began January 17, 2019. Kia's number for this recall is SC172. Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov. |
| RECALL SUBJECT: Incorrect Low Beam Aiming/FMVSS 108 Report Receipt Date: OCT 31, 2018 NHTSA Campaign Number: 18V771000 Component(s): EXTERIOR LIGHTING Potential Number of Units Affected: 1,754 Manufacturer: Kia Motors America NOVEMBER 2018 -- Kia Motors America (Kia) is recalling certain 2019 Kia Forte vehicles equipped with LED headlights. The headlights may not have been manufactured with the correct low beam aiming. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment." If the headlights are not properly aimed, the driver may have reduced visibility, increasing the risk of a crash. Kia will notify owners, and dealers will inspect the headlight aiming and replace the headlights, as necessary, free of charge. The recall is expected to begin November 30, 2018. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC171. Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov. |
| RECALL SUBJECT: Wiring Harness may be Damaged by Fender Report Receipt Date: OCT 25, 2018 NHTSA Campaign Number: 18V754000 Component(s): ELECTRICAL SYSTEM Potential Number of Units Affected: 16,011 Manufacturer: Kia Motors America NOVEMBER 2018 -- Kia Motors America (Kia) is recalling certain 2018 Kia Stinger vehicles. The front wiring harness located in the engine and passenger compartment may get damaged from contacting a burr on the left fender body panel. The damaged wiring harness may short circuit, increasing the risk of a fire. Kia will notify owners, and dealers will inspect the wiring harness for damage. If no damage is found, a cover will be installed. If damage is found, the wiring harness will be repaired and a cover will be installed, free of charge. The recall is expected to begin December 20, 2018. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall SC170. Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov. |
| RECALL SUBJECT: Electrical Resistance at Main Relay May Cause Fire Report Receipt Date: SEP 25, 2018 NHTSA Campaign Number: 18V666000 Component(s): HYBRID PROPULSION SYSTEM Potential Number of Units Affected: 27,030 Manufacturer: Kia Motors America SEPTEMBER 2018 -- Kia Motors America (Kia) is recalling certain 2017-2018 Kia Niro hybrid electric vehicles. The Main Relay within the Power Relay Assembly (PRA) may have inadequate connections between its contacts, causing increased electrical resistance. The increased electrical resistance can overheat the rear seat which is above the PRA, increasing the risk of a fire. Kia will notify owners, and dealers will inspect the Power Relay Assembly (PRA) for damage. If no damage is found, the main relay will be replaced. If damage is found, the PRA will be replaced. These repairs will be performed free of charge. The recall is expected to begin November 23, 2018. Kia's number for this recall is SC168. Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov. |
| RECALL SUBJECT: Steering Column may Separate Report Receipt Date: SEP 21, 2018 NHTSA Campaign Number: 18V656000 Component(s): STEERING Potential Number of Units Affected: 97 Manufacturer: Kia Motors America SEPTEMBER 2018 -- Kia Motors America (Kia) is recalling certain 2018 Kia Sorento vehicles. The cowl crossbar that connects to the Motor Driven Power Steering (MDPS) steering column may be improperly welded, allowing the steering column to separate. If the steering column separates, it can cause a loss of steering ability, increasing the risk of a crash. Kia will notify owners, and dealers will replace the cowl crossbar, free of charge. The recall began October 26, 2018. Kia's number for this recall is SC167. Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov. |
| RECALL SUBJECT: Air Bags/Seat Belt Pretensioners may be Disabled Report Receipt Date: JUN 01, 2018 NHTSA Campaign Number: 18V363000 Component(s): AIR BAGS Potential Number of Units Affected: 507,587 Manufacturer: Kia Motors America JUNE 2018 -- Kia Motors America (Kia) is recalling certain 2010-2013 Kia Forte, Forte Koup, 2011-2013 Kia Optima and 2011-2012 Kia Optima Hybrid and Sedona vehicles. In the event of a crash, the air bag control unit (ACU) may short circuit, preventing the frontal air bags and seat belt pretensioners from deploying. If the frontal air bags and seat belt pretensioners are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems. The remedy for this recall is still under development. Kia's number for this recall is SC165. Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov. |
| RECALL SUBJECT: Power Sliding Door may not Auto-Reverse Report Receipt Date: MAY 23, 2018 NHTSA Campaign Number: 18V338000 Component(s): ELECTRICAL SYSTEM , STRUCTURE Potential Number of Units Affected: 106,428 Manufacturer: Kia Motors America MAY 2018 -- Kia Motors America (Kia) is recalling certain 2015-2018 Kia Sedona vehicles equipped with a power sliding door (PSD). The PSD may not auto-reverse when its closing is obstructed. If the door closes on an occupant, there is an increased risk of an injury. Kia will notify owners, and dealers will reprogram the PSD module software, free of charge. The recall began on June 18, 2018. Kia's number for this recall is SC164. Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov. |
| RECALL: Kia Motors America (Kia) is recalling certain 2017 Kia Niro vehicles; HYBRID PROPULSION SYSTEM RECALL SUBJECT: Clutch Actuator Oil Leak may cause Fire Report Receipt Date: APR 20, 2018 NHTSA Campaign Number: 18V257000 Component(s): HYBRID PROPULSION SYSTEM Potential Number of Units Affected: 27,029 Manufacturer: Kia Motors America MAY 2018 -- Kia Motors America (Kia) is recalling certain 2017 Kia Niro vehicles. The Hydraulic Clutch Actuator (HCA) inner oil seal may leak, allowing oil to accumulate in the cap area, possibly resulting in an electrical short.An electrical short can increase the risk of a fire. Kia will notify owners, and dealers will inspect the HCA caps for leaked oil and replace the HCA assembly if needed, or replace the HCA cap with additional sealant. These repairs will be performed free of charge. The recall is expected to begin June 15, 2018. Kia's number for this recall is SC163. Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov. RECALLED VEHICLES Kia Niro |
| RECALL: Kia is recalling certain 2017-2018 Kia Optima hybrid vehicles RECALL SUBJECT: Voltage Protection Device may Activate Report Receipt Date: MAR 08, 2018 NHTSA Campaign Number: 18V161000 Component(s): HYBRID PROPULSION SYSTEM Potential Number of Units Affected: 1,710 Manufacturer: Kia Motors America MARCH 2018 -- Kia Motors America (Kia) is recalling certain 2017-2018 Kia Optima hybrid vehicles. These vehicles are equipped with a Voltage Protection Device (VPD), designed to protect the high voltage battery module, that may activate inadvertently. If the VPD activates while the vehicle is being operated in Electric Vehicle (EV) mode, there may be a loss of power, increasing the risk of a crash. Kia will notify owners, and dealers will remove the VPD switch and install two newly designed Battery Management Systems (BMS) that contain Overvoltage Protection Devices (OPDs), free of charge. The recall is expected to begin May 3, 2018. Kia's number for this recall is SC162. Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov. RECALLED VEHICLES Kia Optima |
| RECALL: Kia is recalling certain 2018 Kia Sorento vehicles; AIR BAGS Report Receipt Date: DEC 08, 2017 NHTSA Campaign Number: 17V784000 Component(s): AIR BAGS Potential Number of Units Affected: 2,014 DECEMBER 2017 -- Kia Motors America (Kia) is recalling certain 2018 Kia Sorento vehicles. The side curtain air bags on these vehicles have a component that may detach during deployment of the inflatable curtain air bag. If the component detaches during deployment, it may enter the passenger compartment and be a projectile within the vehicle cabin, increasing the risk of injury. Kia will notify owners, and dealers will replace the driver and passenger side curtain air bags, free of charge. The recall is expected to begin in December 2017. Kia's number for this recall is SC159. Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov. RECALLED VEHICLES Kia Sorento |
| RECALL: Kia is recalling certain 2012-2014 Forte and Forte Koup vehicles; SERVICE BRAKES, HYDRAULIC Report Receipt Date: DEC 01, 2017 NHTSA Campaign Number: 17V773000 Component(s): SERVICE BRAKES, HYDRAULIC Potential Number of Units Affected: 134,366 DECEMBER 2017 -- Kia Motors America (Kia) is recalling certain 2012-2014 Forte and Forte Koup vehicles. The brake pedal stopper pad can deteriorate allowing the brake light switch plunger to remain extended when the brake pedal is released. This will allow the brake lights to remain illuminated continuously. It can also allow the shift lever to be moved without depressing the brake pedal, or activate the engine management brake pedal override feature. If the brake light switch plunger does not retract as it should when the brake pedal is not being pressed, the brake lights may stay illuminated preventing accurate communication to following vehicles that the vehicle is slowing or stopping. Additionally, if the brake switch plunger is not retracted, then the transmission can be shifted out of PARK without depressing the brake pedal. Either condition increases the risk of a crash. Kia will notify owners, and dealers will replace the brake pedal stopper pad, free of charge. The recall is expected to begin January 30, 2018. Kia's number for this recall is SC158. Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov. RECALLED VEHICLES Kia Forte |
| RECALL: Kia is recalling certain 2014-2016 Soul and Soul EV vehicles; STEERING Report Receipt Date: SEP 29, 2017 NHTSA Campaign Number: 17V608000 Component(s): STEERING Potential Number of Units Affected: 342,381 OCTOBER 2017 -- Kia Motors America (Kia) is recalling certain 2014-2016 Soul and Soul EV vehicles. The pinion plug may allow the pinion gear to separate from the steering gear assembly. If the pinion gear separates, steering will be lost, increasing the risk of a crash. Kia will notify owners, and dealers will inspect and secure the pinion plug or replace the steering gear assembly, as necessary, free of charge. The recall is expected to begin November 16, 2017. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC155. Note: This recall supersedes campaigns 14V-332 and 15V-736. Vehicles previously remedied under those numbers are being recalled again under this campaign. Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov. RECALLED VEHICLES Kia Soul |
| RECALL: Kia is recalling certain 2017 Sorento vehicles equipped with 3.3L engines; ENGINE AND ENGINE COOLING Report Receipt Date: SEP 21, 2017 NHTSA Campaign Number: 17V586000 Component(s): ENGINE AND ENGINE COOLING Potential Number of Units Affected: 62 SEPTEMBER 2017 -- Kia Motors America (Kia) is recalling certain 2017 Sorento vehicles equipped with 3.3L engines. The engine crankshaft may have been improperly heat treated and may fail. If the crankshaft fails, the engine will stall, increasing the risk of a crash. A failed crankshaft also increases the risk of a fire. Kia will notify owners, and dealers will inspect the crankshaft, and, as necessary, replace the engine sub assembly, free of charge. The recall is expected to begin November 6, 2017. Kia's number for this recall is SC153. Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov. RECALLED VEHICLES Kia Sorento |
| RECALL: Kia is recalling certain 2011-2014 Optima, 2012-2014 Sorento and 2011-2013 Sportage vehicles; ENGINE AND ENGINE COOLING Report Receipt Date: MAR 31, 2017 NHTSA Campaign Number: 17V224000 Component(s): ENGINE AND ENGINE COOLING Potential Number of Units Affected: 618,160 APRIL 2017 -- Kia Motor Company (Kia) is recalling certain 2011-2014 Optima, 2012-2014 Sorento and 2011-2013 Sportage vehicles. Machining errors during the engine manufacturing process may cause premature bearing wear within the engine. Bearing wear may result in the engine seizing, increasing the risk of a crash. Kia will notify owners, and dealers will inspect the engine assembly, replacing it necessary, free of charge. The recall is expected to begin May 25, 2017. Kia's number for this recall is SC147. Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov. MORE RECALL INFO Kia Optima Kia Sorento Kia Sportage |
| RECALL: Kia is recalling certain 2017 Cadenza vehicles; SERVICE BRAKES, HYDRAULIC Report Receipt Date: MAR 16, 2017 NHTSA Campaign Number: 17V190000 Component(s): SERVICE BRAKES, HYDRAULIC Potential Number of Units Affected: 47 MARCH 2017 -- Kia Motors America (Kia) is recalling certain 2017 Cadenza vehicles. The brake vacuum hose on the affected vehicles may kink, reducing braking performance. Reduced braking performance can lengthen the distance needed to stop the vehicle, increasing the risk of a crash. Kia will notify owners, and dealers will inspect the brake vacuum hose, replacing it as necessary, free charge. The recall began on April 17, 2017. Kia's number for this recall is SC146. Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov. MORE RECALL INFO Kia Cadenza |
| RECALL: Kia is recalling certain 2017 Niro vehicles; STEERING Report Receipt Date: MAR 10, 2017 NHTSA Campaign Number: 17V159000 Component(s): STEERING Potential Number of Units Affected: 135 MARCH 2017 -- Kia Motors America (Kia) is recalling certain 2017 Niro vehicles. The affected vehicles may have a damaged Motor Driven Power Steering (MDPS) connector resulting in a loss of electric power steering assistance. Loss of power steering assist would require higher steering effort, especially at lower speeds, which may increase the risk of a crash. Kia will notify owners, and dealers will replace the MDPS motor, free of charge. The recall is expected to begin April 7, 2017. Kia's number for this recall is SC145. Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov. MORE RECALL INFO Kia Niro |
| RECALL: Kia Motors America is recalling certain 2008-2009 Kia Sportage vehicles; ELECTRICAL SYSTEM Report Receipt Date: NOV 10, 2016 NHTSA Campaign Number: 16V815000 Component(s): ELECTRICAL SYSTEM Potential Number of Units Affected: 71,704 NOVEMBER 2016 -- Kia Motors America (Kia) is recalling certain model year 2008-2009 Kia Sportage vehicles manufactured August 9, 2007, to May 13, 2009. The wire harness cover on the Hydraulic Electronic Control Unit (HECU) may be improperly sealed allowing water to get onto the HECU circuit board. If the water is contaminated with salt, such as could occur from melted snow, the wire harness connector pins may corrode and the circuit board may short circuit. If the HECU short circuits, there is an increased risk of an engine compartment fire. Kia will notify owners, and dealers will inspect the connector pins for corrosion, if no corrosion is found, the connector cover will be replaced. If corrosion is present, the dealer will replace the HECU assembly and the connector cover, free of charge. The recall is expected to begin November 28, 2016. Kia's number for this recall is SC138. Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov. MORE RECALL INFO Kia Sportage |
| RECALL: Kia is recalling certain 2016 Kia Sorento vehicles; SEATS Report Receipt Date: OCT 24, 2016 NHTSA Campaign Number: 16V770000 Component(s): SEATS Potential Number of Units Affected: 1,408 NOVEMBER 2016 -- Kia Motors America (Kia) is recalling certain model year 2016 Kia Sorento vehicles manufactured March 3, 2016 to March 21, 2016. The driver's seatback frame may have been produced with inadequate weld joints and, as a result, the seatback may not function as designed in the event of a rear-end collision. In the event of a crash, the driver seatback frame could break and fail to restrain a seat occupant, increasing the risk of injury. Kia will notify owners, and dealers will inspect the welds and replace the driver seatback frame, as necessary, free of charge. The recall is expected to begin on December 9, 2016. Kia's number for this recall is SC140. Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov. MORE RECALL INFO Kia Sorento |
| RECALL: Kia is recalling certain 2016 Kia Optima vehicles; POWER TRAIN Report Receipt Date: OCT 03, 2016 NHTSA Campaign Number: 16V705000 Component(s): POWER TRAIN Potential Number of Units Affected: 12,21 OCTOBER 2016 -- Kia Motors America (Kia) is recalling certain model year 2016 Kia Optima vehicles manufactured November 13, 2015, to April 23, 2016 and equipped with a 2.4l engine. The right front axle driveshaft may crack and fail. If the driveshaft cracks and separates from the vehicle, it will not be able to move forward. Additionally, if the parking brake is not applied upon exiting the vehicle, the vehicle may roll. Either scenario can increase the risk of a crash. Kia will notify owners, and dealers will replace the front axle driveshaft, free of charge. The recall is expected to begin November 29, 2016. Kia's number for this recall is SC139. Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov. MORE RECALL INFO Kia Optima |
| RECALL: Kia is recalling certain 2016 Sorento vehicles; SUSPENSION Report Receipt Date: JUN 29, 2016 NHTSA Campaign Number: 16V480000 Component(s): SUSPENSION Potential Number of Units Affected: 7,901 JULY 2016 -- Kia Motors America (Kia) is recalling certain model year 2016 Sorento vehicles. A component of the rear suspension may not be properly welded. The improper weld may break, affecting the rear suspension alignment, thereby increasing the risk of a crash. Kia will notify owners, and dealers will inspect the welds at the rear suspension cross-member, replacing the rear cross-member assembly, as necessary, free of charge. The recall began July 27, 2016. Kia's number for this recall is SC137. Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov. MORE RECALL INFO Kia Sorento |
| RECALL: Kia is recalling certain model year 2006-2014 Kia Sedona vehicles; LATCHES/LOCKS/LINKAGES Report Receipt Date: JUN 01, 2016 NHTSA Campaign Number: 16V389000 Component(s): LATCHES/LOCKS/LINKAGES Potential Number of Units Affected: 219,800 JUNE 2016 -- Kia Motors Corporation (Kia) is recalling certain model year 2006-2014 Kia Sedona vehicles manufactured from June 15, 2005, through April 04, 2014. In the affected vehicles, the secondary hood latch may bind and remain in the unlatched position when the hood is closed. If the primary latch is inadvertently released and the secondary latch is not engaged, the hood could unexpectedly open while driving, increasing the risk of a vehicle crash. Kia will notify owners and dealers will replace the secondary hood latch or clean and lubricate the latch, depending on the vehicle's location and the condition of the latch. These repairs will be performed free of charge. The recall is expected to begin on July 25, 2016. Kia's recall number is SC134. Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov. MORE RECALL INFO Kia Sedona |
| RECALL: Kia is recalling certain 2006-2012 Kia Sedona vehicles; SUSPENSION Report Receipt Date: JUN 01, 2016 NHTSA Campaign Number: 16V387000 Component(s): SUSPENSION Potential Number of Units Affected: 97,884 JUNE 2016 -- Kia Motors Corporation (Kia) is recalling certain model year 2006-2012 Kia Sedona vehicles manufactured from June 15, 2005, through August 14, 2012 and originally sold in, or currently registered in Alaska, Connecticut, Delaware, Illinois, Indiana, Iowa, Kansas, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, Nebraska, New Hampshire, New Jersey, New York, North Dakota, Ohio, Pennsylvania, Rhode Island, South Dakota, Utah, Vermont, West Virginia, Wisconsin and the District of Columbia. In the affected vehicles, the front lower control arms may break due to corrosion from salt water exposure such as from road salt use. A broken control arm can result in the loss of control of the vehicle, increasing the risk of a crash. Kia will notify owners and dealers will replace the front lower control arms on 2006-2007 models. 2008-2012 models will either have their front lower control arms replaced or additional anti-corrosion coating will be applied. These repairs will be performed free of charge. The recall is expected to began on July 25, 2016. Kia's number for this recall is SC133. Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov. MORE RECALL INFO Kia Sedona |
| RECALL: Kia is recalling certain 2013 Forte vehicles; SEAT BELTS Report Receipt Date: MAY 17, 2016 NHTSA Campaign Number: 16V312000 Component(s): SEAT BELTS Potential Number of Units Affected: 5,245 JUNE 2016 -- Kia Motors America (Kia) is recalling certain model year 2013 Forte vehicles manufactured September 10, 2012, to October 31, 2012. The screws that hold the front seatbelt retractor retaining plates may not have been properly tightened, and as a result, the seatbelt retractor retaining plates may break in a crash. If a retaining plate breaks during a crash, pieces of the plate could strike the occupants, increasing risk of injury. Kia will notify owners, and dealers will inspect and replace both front seatbelt assemblies, as necessary, free of charge. The recall is expected to begin June 30, 2016. Kia's number for this recall is SC132. Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov. MORE RECALL INFO Kia Forte |
| RECALL: Kia is recalling certain 2016 Kia Optima vehicles; AIR BAGS Report Receipt Date: APR 21, 2016 NHTSA Campaign Number: 16V231000 Component(s): AIR BAGS Potential Number of Units Affected: 17 MAY 2016 -- Kia Motors America (Kia) is recalling certain model year 2016 Kia Optima vehicles manufactured November 10, 2015, to February 12, 2016. In these vehicles, a chemical enhancer required for the for the second stage deployment of the driver's frontal air bag was not loaded, resulting in the second stage not deploying in necessitating crashes. If the second stage air bag does not deploy it increases the risk of injury or death. Kia will notify owners, and dealers will replace the driver's frontal air bag module, free of charge. The recall is expected to begin in May 2016. Kia's number for this recall is SC131. Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov MORE RECALL INFO Kia Optima |
| RECALL: Kia is recalling certain 2015-2016 K900 vehicles; EXTERIOR LIGHTING Report Receipt Date: APR 12, 2016 NHTSA Campaign Number: 16V210000 Component(s): EXTERIOR LIGHTING Potential Number of Units Affected: 3,099 APRIL 2016 -- Kia Motors America (Kia) is recalling certain model year 2015-2016 K900 vehicles manufactured December 18, 2013 to January 11, 2016 and equipped with LED headlights. In the affected vehicles, when using the multi-function light switch in "AUTO" mode, electrical resistance may build in the switch and result in the headlights flickering or turning off when driving.Loss of headlight illumination may reduce visibility and increase the risk of a crash. Kia will notify owners, and dealers will replace the multi-function switch, free of charge. The recall is expected to begin May 27, 2016. Kia's number for this recall is SC130. Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov. MORE RECALL INFO Kia K900 |
| RECALL: Kia Motors America (Kia) is recalling certain 2011 Forte vehicles; POWER TRAIN Report Receipt Date: FEB 05, 2016 NHTSA Campaign Number: 16V070000 Component(s): POWER TRAIN Potential Number of Units Affected: 10,240 FEBRUARY 2016 -- Kia Motors America (Kia) is recalling certain model year 2011 Forte vehicles manufactured August 27, 2010, to November 11, 2010. The affected vehicles have a transmission fluid cooler hose that may have been improperly manufactured, resulting in a transmission fluid leak. If enough transmission fluid leaks out, the transmission may not function properly and the vehicle may stop moving, increasing the risk of a crash. Kia will notify owners, and dealers will replace the transmission cooler hose, free of charge. The recall began March 30, 2016. Kia's number for this recall is SC129. Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov. MORE RECALL INFO Kia Forte |
| RECALL: Kia Motors America is recalling certain 2014-2016 Kia Soul and Soul EV vehicles; STEERING Report Receipt Date: NOV 06, 2015 NHTSA Campaign Number: 15V736000 Component(s): STEERING Potential Number of Units Affected: 256,459 NOV 2015 -- Kia Motors America (Kia) is recalling certain model year 2014-2016 Kia Soul and Soul EV vehicles manufactured January 18, 2014, to September 30, 2015. In the affected vehicles, the adhesive used to secure the steering pinion gear to the steering gear assembly may have insufficient strength, and as a result, the pinion gear may separate from the steering gear assembly. If the pinion gear separates, there would be a loss of steering which could increase the risk of a crash. Kia will notify owners, and dealers will inspect and, if necessary, replace the pinion plug that secures the pinion gear. Dealers will also install a set bolt for additional reinforcement. These repairs will be performed free of charge. The recall is expected to begin December 22, 2015. Kia's number for this recall is SC125. Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov. MORE RECALL INFO Kia Soul |
| RECALL: Kia is recalling certain 2011-2013 Kia Sorento vehicles; POWER TRAIN Report Receipt Date: OCT 06, 2015 NHTSA Campaign Number: 15V626000 Component(s): POWER TRAIN Potential Number of Units Affected: 377,062 OCT 2015 -- Kia Motors America (Kia) is recalling certain model year 2011-2013 Kia Sorento vehicles manufactured October 19, 2009, to January 31, 2013. In the affected vehicles, if excessive force is applied to the gear shift lever, the brake-shift interlock mechanism may chip or crack allowing the transmission being able to be shifted out of "Park" without the brakes being depressed. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection." Without requiring the brake to be pressed, the vehicle may be unintentionally shifted out of Park, allowing it to roll, which may result in a crash. Kia will notify owners, and dealers will replace the brake-shift interlock mechanism, free of charge. The recall is expected to begin November 24, 2015. Kia's number for this recall is SC124. Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov. MORE RECALL INFO Kia Sorento |
| RECALL: Kia Motors America (Kia) is recalling certain model year 2011 Sportage vehicles; SERVICE BRAKES, HYDRAULIC Report Receipt Date: JUN 09, 2015 NHTSA Campaign Number: 15V360000 Component(s): SERVICE BRAKES, HYDRAULIC Potential Number of Units Affected: 7,722 JUNE 2015 -- Kia Motors America (Kia) is recalling certain model year 2011 Sportage vehicles manufactured March 7, 2011, to June 8, 2011. In the affected vehicles, the brake light switch may intermittently fail. Whenever the brake switch is not working, the brake lights will not illuminate, reducing the ability to warn other motorists of the driver's intentions of stopping, increasing the risk of a crash. Kia will notify owners, and dealers will replace the brake light switch, free of charge. The recall is expected to begin in July 2015. Kia's number for this recall is SC121. Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov. MORE RECALL INFO Kia Sportage |
| RECALL: Kia is recalling certain 2014-2015 Soul and Soul electric vehicles; VEHICLE SPEED CONTROL Report Receipt Date: MAR 02, 2015 NHTSA Campaign Number: 15V123000 Component(s): VEHICLE SPEED CONTROL Potential Number of Units Affected: 208,858 MARCH 2015 -- Kia Motors America (Kia) is recalling certain model year 2014-2015 Soul and Soul electric vehicles manufactured July 21, 2013, to January 8, 2015. A section of the accelerator pedal may bend and fracture. If the vehicle has a bent or broken accelerator pedal, the driver may have difficulty accelerating the vehicle, increasing the risk of a crash. Kia will notify owners, and dealers will add a supporting rubber underneath the pedal stopper, free of charge. The recall is expected to begin March 24, 2015. Kia's number for this recall is SC116. Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov. MORE RECALL INFO Kia Soul Kia Soul electric |
| RECALL: Kia is recalling certain 2014 Kia Forte vehicles; ELECTRICAL SYSTEM Report Receipt Date: JAN 16, 2015 NHTSA Campaign Number: 15V015000 Component(s): ELECTRICAL SYSTEM Potential Number of Units Affected: 86,880 JANUARY 2015 -- Kia Motors America (Kia) is recalling certain model year 2014 Kia Forte vehicles manufactured December 5, 2012, to April 17, 2014. In the affected vehicles, the cooling fan resistor may overheat and melt. If the cooling fan resistor overheats and melts, there is an increased risk of a vehicle fire. Kia will notify owners, and for vehicles produced from December 5, 2012 to January 27, 2014, dealers will replace the cooling fan resistor and multi-fuse unit. For vehicles produced from January 28, 2014 to April 17, 2014, dealers will replace the multi-fuse unit only. Owners of vehicles with a 1.8L engine will also have the engine control unit software updated. The recall is expected to begin February 24, 2015. Kia's number for this recall is SC113. Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov. MORE RECALL INFO Kia Forte |
| RECALL: Kia is recalling certain model year 2010-2013 Kia Soul vehicles; STRUCTURE Report Receipt Date: DEC 29, 2014 NHTSA Campaign Number: 14V822000 Component(s): STRUCTURE Potential Number of Units Affected: 95,314 JANUARY 2015 -- Kia Motors America (Kia) is recalling certain model year 2010-2013 Kia Soul vehicles manufactured January 8, 2009, to October 2, 2013, equipped with a sun roof. A headliner plate may detach during deployment of the curtain air bag. A detached headliner plate may increase the risk of injury to the occupant during a vehicle crash. Kia will notify owners, and dealers will install industrial adhesive strips to secure the headliner plates, free of charge. The recall is expected to begin February 2, 2015. Kia's number for this recall is SC112. Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov. MORE RECALL INFO Kia Soul |
| RECALL: Kia is recalling certain model year 2014 Kia Soul vehicles; STEERING GEAR Report Receipt Date: JUN 17, 2014 NHTSA Campaign Number: 14V332000 Component(s): STEERING GEAR Potential Number of Units Affected: 51,641 JULY 2014 -- Kia Motors Corporation (Kia) is recalling certain model year 2014 Kia Soul vehicles manufactured July 21, 2013, through January 17, 2014. In the affected vehicles, the plug that secures the pinion gear to the steering gear assembly may loosen due to an improper application of thread-locking adhesive during the assembly process. As a result, the pinion gear can separate from the steering gear assembly, causing a loss of steering, thereby increasing the risk of a crash. Kia will notify owners, and dealers will replace the pinion plug with a new pinion plug which has properly applied thread-locking adhesive, free of charge. The recall is expected to begin in July 2014. Kia's number for this recall is SC108. Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov MORE RECALL INFO Kia Soul |
| RECALL: Kia is recalling certain 2014 Cadenza vehicles; WHEELS Report Receipt Date: MAY 30, 2014 NHTSA Campaign Number: 14V289000 Component(s): WHEELS Potential Number of Units Affected: 3,107 JUNE 2014 -- Kia Motors Corporation (Kia) is recalling certain model year 2014 Cadenza vehicles manufactured February 1, 2013, through August 27, 2013, and equipped with 19" non-chrome aluminum wheels. The wheels on the affected vehicles may fracture from impacts such as large, deep potholes. A wheel fracture could cause the circular rim to separate, resulting in a loss of tire pressure, increasing the risk of a crash. Kia will notify owners, and dealers will replace the wheels with new wheels, free of charge. The recall is expected to begin in June 2014. Kia's number for this recall is SC107. Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov. MORE RECALL INFO Kia Cadenza |
| RECALL: Kia Motors is recalling certain model year 2014 Kia Sportage vehicles; TIRES; RIMS, EQUIPMENT Report Receipt Date: JAN 27, 2014 NHTSA Campaign Number: 14V023000 Component(s): TIRES; RIMS, EQUIPMENT Potential Number of Units Affected: 11,961 FEBRUARY 2014 -- Kia Motors Corporation (Kia) is recalling certain model year 2014 Kia Sportage vehicles manufactured September 30, 2013, through January 11, 2014. The certification label has incorrect tire pressure information printed on it, listing a specification that is 1 or 2 psi below the correct information. Thus, these vehicles do not conform to Federal Motor Vehicle Safety Standard (FMVSS) 110, "Tire Selection and Rims for Passenger Cars." Maintaining tire pressure below the recommmend specification could result in premature tire wear, increasing the risk of a crash. Kia will notify owners, and dealers will correct the label information, and owners will also receive a sticker to put into the owners manual, free of charge. The recall is expected to begin in February 2014. . Kia's recall campaign number is SC103. Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov. MORE RECALL INFO Kia Sportage |
| RECALL: Kia Motors is recalling certain model year 2014 Kia Sportage vehicles; TIRES; RIMS, EQUIPMENT Report Receipt Date: JAN 27, 2014 NHTSA Campaign Number: 14V023000 Component(s): TIRES; RIMS, EQUIPMENT Potential Number of Units Affected: 11,961 FEBRUARY 2014 -- Kia Motors Corporation (Kia) is recalling certain model year 2014 Kia Sportage vehicles manufactured September 30, 2013, through January 11, 2014. The certification label has incorrect tire pressure information printed on it, listing a specification that is 1 or 2 psi below the correct information. Thus, these vehicles do not conform to Federal Motor Vehicle Safety Standard (FMVSS) 110, "Tire Selection and Rims for Passenger Cars." Maintaining tire pressure below the recommmend specification could result in premature tire wear, increasing the risk of a crash. Kia will notify owners, and dealers will correct the label information, and owners will also receive a sticker to put into the owners manual, free of charge. The recall is expected to begin in February 2014. . Kia's recall campaign number is SC103. Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov. MORE RECALL INFO Kia Sportage |
| RECALL: Kia is recalling certain 2006-2012 Kia Sedona vehicles: SUSPENSION Report Receipt Date: NOV 05, 2013 NHTSA Campaign Number: 13V550000 Component(s): SUSPENSION Potential Number of Units Affected: 79,867 NOVEMBER 2013 - Kia Motors Corporation (Kia) is recalling certain model year 2006-2012 Kia Sedona vehicles manufactured from June 15, 2005, through August 14, 2012 originally sold in, or currently registered in Massachusetts, Maryland, Michigan, New Hampshire, New York, Pennsylvania, Vermont, Wisconsin, Connecticut, Delaware, Iowa, Illinois, Indiana, Maine, Minnesota, Missouri, New Jersey, Ohio, Rhode Island, West Virginia or the District of Columbia. In the affected vehicles, the front lower control arms may break due to corrosion resulting from prolonged exposure to salty environments. A broken control arm can result in the loss of control of the vehicle, increasing the risk of a crash. Kia will notify owners and dealers will inspect the degree of corrosion of the front lower control arms, and will either rustproof or replace them, free of charge. The recall is expected to begin in December 2013. Kia's recall number is SC100. Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov. MORE RECALL INFO Kia Sedona |
| RECALL: Kia Motors Corp. is recalling certain model year 2014 front wheel drive Sorento vehicles Report Receipt Date: AUG 13, 2013 NHTSA Campaign Number: 13V356000 Component(s): POWER TRAIN Potential Number of Units Affected: 9,345 AUGUST 2013 - Kia Motors Corp. is recalling certain model year 2014 front wheel drive Sorento vehicles manufactured January 7, 2013, through March 12, 2013; and equipped with 2.4 liter engines. Due to a manufacturing issue, the right front axle shaft may fracture. A fractured front axle may result in a loss of power to the wheels. Additionally, if the vehicle is parked without the parking brake applied, it may roll away. Either condition increases the risk of a crash. Kia will notify owners, and dealers will replace the front axle shaft assembly, free of charge. The recall is expected to begin in September 2013. Kia's recall number is SC099. Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov. MORE RECALL INFO Kia Sorento |
| RECALL: Kia is recalling 2007-2010 Rondo and Sportage, 2007-2011 Sorento, 2007 Sedona, 2010-2011 Soul, and 2011 Optima vehicles Report Receipt Date: APR 01, 2013 NHTSA Campaign Number: 13V114000 Component(s): EXTERIOR LIGHTING , SERVICE BRAKES, HYDRAULIC Potential Number of Units Affected: 623,658 APRIL 2013 -- Kia Motors Corporation (Kia) is recalling certain model year 2007-2010 Rondo and Sportage, model year 2007-2011 Sorento, model year 2007 Sedona, model year 2010-2011 Soul, and model year 2011 Optima vehicles. The stop lamp switch in the affected vehicles may malfunction. A malfunctioning stop lamp switch may cause the brake lights to not illuminate when the brake pedal is depressed or may cause an inability to deactivate the cruise control by depressing the brake pedal. Additionally, a malfunctioning stop lamp switch may also result in intermittent operation of the push-button start feature, affect the operation of the brake-transmission shift interlock feature preventing the shifter from being moved out of the PARK position and causing the Electronic Stability Control (ESC) malfunction light to illuminate. Failure to illuminate the stop lamps during braking or inability to disengage the cruise control could increase the risk of a crash. Kia will send an interim notification to owners in May 2013. When parts are available, owners will receive a second notification and dealers will replace the stop lamp switch, free of charge. Kia's recall campaign number is SC098. Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov. MORE RECALL INFO Kia Optima Kia Rondo Kia Sedona Kia Sorento Kia Soul Kia Sportage |
Free Case Review
